Fuse box diagram (fuse layout), location and also assignment that fuses and also relays Ford traveler / traveler Sport (U152; 2000, 2001, 2002, 2003, 2004, 2005).
You are watching: 2005 ford explorer fuse box location

Checking and Replacing Fuses
Fuses and circuit breakers protect your vehicle’s electrical system native overloading. If electrical parts in your auto are no working, the mechanism may have been overloaded and blown a fuse or tripped a circuit breaker. Before you change or repair any electrical parts, examine the suitable fuses or circuit breakers.
To examine a fuse, look at the silver-colored tape inside the fuse. If the band is broken or melted, replace the fuse.
Notice
Before replacing fuses inspect that the crucial has been removed from the ignition and also that all the solutions are switched turn off and/or disengaged.Always disconnect the battery prior to servicing high present fuses.Always change a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and also could begin a fire.Never change a broken fuse v anything various other than a brand-new fuse. Use always an undamaged fuse that the exact same color.If a fuse blows again call a qualified service center.Passenger Compartment Fuse Box
The fuse dashboard is located below the instrument panel on the driver’s side.


1 | 30 | Memory chair module, Driver strength seat (2003-2005), Driver power lumbar (2005) |
2 | 20 | Heated seat (2001-2002), Moonroof |
3 | 20 | Radio, Amplifier, power antenna (2001-2002), DVD |
4 | 5 | Front wiper module |
5 | 15 | Flasher relay (Turn, hazards) |
6 | 10 | Right horn (2001-2002), Key-in-chime (2003-2005) |
7 | 15 | Heated mirrors |
8 | 5 | Heated PCV (2004-2005; 4.0L engine only) |
9 | — | Not used (spare) |
10 | 10 | Heated backlight relay coil, Heated seat module (2001-2002), Temp mix actuator (2001-2002), A/C clutch contact |
11 | 20 | Heated seats (2003-2005) |
12 | 5 | Foglamp switch (2001-2002), 4x4 module |
13 | 5 | Overdrive cancel switch, Flex fuel sender (2001-2003) |
14 | 5 | PATS module |
15 | 5 | Rear wiper module, Cluster, TPMS (2001-2003) |
16 | 5 | Power mirror, hand-operated climate control, TPMS |
17 | 15 | Delayed acc. Coil, Battery saver, inner lamps (front and also rear), gloves compartment lamp |
18 | 10 | Left horn (2001-2003), flexible fuel pump (2004-2005) |
19 | 10 | RCM, PAD indicator (2001-2002) |
20 | 5 | Memory driver seat switch, Driver seat module, Body defense Module (BSM), PATS LED, Sunload sensor (2001-2003) |
21 | 5 | Instrument cluster, Compass, Flasher coil |
22 | 10 | ABS, IVD Controller |
23 | 15 | 2001-2003:Brake pedal place switch, Driver brake used relay, redundant cruise deactivate switch |
24 | 15 | Cigar lighter, OBD II, Neutral tow |
25 | 5 | Mode-Temperature actuator for assistant climate control, Trailer tow battery charge coil, TPMS (2004-2005) |
26 | 7.5 | Reverse park aid, Brake change interlock, technique lamp relay coil (2001-2002), IVD switch |
27 | 7.5 | Automatic dimming mirror, Digital transmission variety sensor, backup lamps |
28 | 5 | Radio (Start)/DVD (Start) |
29 | 10 | Digital transmission variety sensor, PWR feeding to fuse #28 (Start feed) |
30 | 5 | Daytime running Lamps (DRL), far solenoid, DEATC climate controller, manual climate control, manual climate control temp blend actuator |
These relays are located on the turning back side that the passenger compartment fuse panel.

1 | Flasher relay |
2 | Rear defrost |
3 | Delayed accessory relay |
4 | Open |
5 | Battery saver |
6 | Open |
7 | Open |
Engine Compartment Fuse Box
The power distribution box is located in the engine compartment.


1 | 60 | PJB |
2 | 30 | BSM |
3 | 20 | GCC pusher fan (2001-2002; violin only) |
4 | 30 | Rear defrost |
5 | 40 | Anti-lock Brake system (ABS) pump |
6 | 60 | Delayed accessory, Power home windows (2004-2005), Audio (2004-2005) |
7 | 20 | Power suggest #2 |
8 | 30 | 4x4 transition motor (2004-2005) |
9 | 20 | Power point #1 |
10 | 30 | ABS module (valves) |
11 | 40 | PTEC (2001-2003), Powertrain regulate Module (PCM) (2004-2005) |
12 | 50 | Ignition relay/Starter relay |
13 | 40 | Trailer tow battery. Trailer tow revolve signals |
14 | 10 | Daytime to run Lamps (DRL) (Canada), Foglamps (2001-2002; violin only) |
15 | 15 | Memory (KAPWR) (2001-2002), memory (PCM/DEATC/Cluster) (2003-2005), Courtesy lamps (2003-2005) |
16 | 15 | Headlamp move (2001-2003), Foglamp switch (2003), Park lamps (2004-2005), Autolamp parklamps (2004-2005), former foglamps relay coil (2004-2005) |
17 | 20 | 4x4 (v-batt 2) (2001-2003) |
5 | Two-speed 4x4 (relay coils) (2004-2005) | |
18 | 20 | 4x4 (v-batt 1) (2001-2003), PCM with two-speed 4x4 clutch (2004-2005) |
19 | 20 | High beam relay |
20 | 30 | Trailer electrical brake module |
21 | 30 | Front wiper motor |
22 | 20 | Autolamp; low beam |
23 | 30 | Ignition switch, PCM diode (2004-2005) |
24 | 20 | Rear fog lamps (2001-2002; violin only) |
25 | 15 | Brake on-off (2004-2005) |
26 | 15 | Fuel pump (2001-2003) |
20 | Fuel pump (2004-2005) | |
27 | 20 | Trailer tow lamps, Trailer tow back-up |
28 | 20 | Horn relay |
29 | 60 | PJB |
30 | 20 | Rear wiper motor |
31 | — | Not used |
32 | — | Not used |
33 | 30 | Auxiliary blower motor |
34 | 30 | Power seats, adjustable pedals |
35 | 20 | Rear power allude (2001-2002) |
36 | 40 | Blower motor |
37 | 15 | A/C clutch relay/Transmission |
38 | 15 | Coil on plug (2001-2003), HEGO (2004-2005), VMV (2004-2005), CMS (2004-2005), ESM (2004-2005), CVS (2004-2005) |
39 | 15 | Injectors/Fuel pump relay |
40 | 15 | PTEC power (2001-2003), PCM strength (2004-2005) |
41 | 15 | HEGO (2001-2003), VMV (2001-2003), CMS (2001-2003), PTEC (2001-2003), Coil ~ above plug (2004-2005; 4.6L engine only), Ignition coil (2004-2005; 4.0L engine only) |
42 | 10 | Right low beam |
43 | 10 | Left short beam |
44 | 15 | Front foglamps |
45 | 5 | Brake press switch (2001-2002) |
2 | Brake press switch (ABS) (2003-2005) | |
46 | 20 | High beams |
62 | 30 | Circuit Breaker: Delayed accessory (2001-2002), Power windows circuit breaker (2003-2005) |
Relay | ||
47 | Horn relay | |
48 | Fuel pump relay | |
49 | High beam relay | |
50 | Fog desk lamp relay | |
51 | Police IVD relay | |
DRL relay (Canada) | ||
52 | A/C clutch relay | |
53 | Trailer tow ideal turn | |
54 | Trailer tow left turn | |
55 | Blower engine relay | |
56 | Starter relay | |
57 | PTEC relay | |
PCM relay | ||
58 | Ignition relay | |
59 | Driver brake used or DRL relay (Canada only) | |
Diode | ||
60 | PCM diode | |
61 | A/C clutch diode |
Rear Relay Box
The relay crate is situated on the behind passenger side 4 minutes 1 trim panel.

14 | Not used |
15 | Trailer tow back- increase lamps |
16 | Not used |
17 | Not used |
18 | Not used |
19 | Trailer tow park lamps |
20 | Trailer tow battery charge |
21 | Not used |
22 | Approach lamps |
23 | Not used |
Diode | |
3 | Not used |
4 | Not used |
The relay crate is located on the front right fender fine underneath the speed manage module (Canadian vehicles equipped through AdvanceTrac).


This website uses cookies to improve your experience. We"ll assume you"re ok v this, but you have the right to opt-out if friend wish. Cookie settingsACCEPT
Privacy & cookies Policy
close
Privacy Overview
This website supplies cookies to boost your experience while friend navigate v the website. The end of this cookies, the cookies that space categorized as necessary are save on computer on your internet browser as lock are essential for the working of an easy functionalities of the website. We additionally use third-party cookies that help us analyze and understand exactly how you usage this website. This cookies will certainly be save on computer in your web browser only with your consent. You additionally have the choice to opt-out of this cookies. But opting out of some of these cookies may have an effect on your searching experience.
Necessary cookies space absolutely necessary for the website to function properly. This category only includes cookies the ensures simple functionalities and also security attributes of the website. This cookies perform not save any an individual information.
See more: Driving Distance From Lexington Ky To Indianapolis In Gton From Indianapolis
Any cookies that might not be an especially necessary because that the website to role and is provided specifically to collect user personal data via analytics, ads, various other embedded materials are termed as non-necessary cookies. It is mandatory to procure user consent prior to running these cookie on her website.